09 trike question.
 

Mornin Boys,
I have one of these. It's an 09.

http://img.photobucket.com/albums/v3...ke/trike-2.jpg



Does anybody know what goes on the top outlet of one of these? And there is also a smaller out let on the bottom of it. The one that is hooked up goes to the exhaust, before the muffler.

http://img.photobucket.com/albums/v3.../hellifIno.jpg

On my Honda Reflex, it's called the "air injection control valve". It is part of the emissions equipment. That top outlet likely has a hose that comes from the airbox. That valve injects filtered air into the exhaust to help completely burn any left over unburned gasses coming from the engine. Also, if your muffler is like the Honda muffler, it has catalytic converter incorporated inside of it to help with emissions as well.

Have you traced where the small hose goes? On my Reflex the small hose goes up to a T-connector. At that T-connector one small hose goes to a small outlet from somewhere near the top side of the crankcase and picks up fumes that may have gotten past the piston. The other small hose from that goes to another small gizmo with 3 hose connections on it. (I'm pretty sure, though I don't have it in front of me now to check it for sure) On that gizmo , one of the other 2 comes from the carb and the other from the fuel evap canister somewhere near the gas tank.

Hope I didn't take you too far into the woods with all that. I'm not sure if your bike is set up in a similar way as mine. Most of these scooter motors are alike in a lot of ways so some parts may look slightly different and be placed in a slightly different place, but they are pretty basic and are hooked up similarly. But don't take it as gospel from me and it would actually be best to consult a service manual specific to you bike or compare to another bike like yours that has all the hoses hooked up properly.

HTH

very similar Not sure if or how it may be affecting performance for your bike with those hoses not hooked up, but it might be.

On my Xingyue 150ZK Auto Moto trike the emissions canister top hose comes from the air box- the bottom smaller hose goes to the differential,another hose goes from the canister back to the air box and gases are re introduced into the carb and burned. The canister is crucial to allowing all these China scooters into the USA. Last year Auto Moto went oob because of failed muffler emissions by customs. Their entire shipment of trikes were sent back to China