Register FAQ Community Calendar Today's Posts Search
Go Back   ScootDawg Forums > Search Forums
Reload this Page Search Results
Page 1 of 2 1 2
Showing results 1 to 25 of 41
Search took 0.01 seconds. Search: Posts Made By: DW
Forum: 125cc - 249cc 12-05-2013, 02:31 AM
Replies: 6
Views: 4,670
Posted By DW
If the brake light comes on when you squeeze the...

If the brake light comes on when you squeeze the brake, the safety switches are fine. They switch the + on the starter relay. The kill and start switches control the - side of the relay.
Forum: 125cc - 249cc 07-08-2013, 12:51 AM
Replies: 7
Views: 14,223
Posted By DW
pull the spark plug and see how easy it turns

pull the spark plug and see how easy it turns
Forum: 125cc - 249cc 07-05-2013, 09:55 PM
Replies: 7
Views: 14,223
Posted By DW
Make sure you get the same voltage reading at the...

Make sure you get the same voltage reading at the solenoid and starter connections as you do at the battery. Must be 12volts or better.
Forum: 125cc - 249cc 07-03-2013, 02:52 AM
Replies: 7
Views: 14,223
Posted By DW
Check your battery connections where they connect...

Check your battery connections where they connect to the wire.
Check your engine to frame ground.
New batteries aren't always fully charged.
Forum: 125cc - 249cc 06-27-2013, 09:52 PM
Replies: 8
Views: 7,748
Posted By DW
If you get a vacuum at the exhaust your valves...

If you get a vacuum at the exhaust your valves are to tight or your timing is off.
Forum: 125cc - 249cc 06-20-2013, 03:45 PM
Replies: 4
Views: 4,290
Posted By DW
22oz of 15w40 is what I use. Usually sold by the...

22oz of 15w40 is what I use. Usually sold by the gallon for diesel engines.
Forum: 125cc - 249cc 06-10-2013, 11:07 PM
Replies: 35
Views: 69,997
Posted By DW
Is it safe to assume that you checked each stator...

Is it safe to assume that you checked each stator terminal individually with the black probe to a good engine ground and the red probe on one wire at a time?

You didn't state which wires you...
Forum: 125cc - 249cc 06-10-2013, 07:02 PM
Replies: 35
Views: 69,997
Posted By DW
Isolate the yellow stator wire by removing it...

Isolate the yellow stator wire by removing it from the connector. Start the engine and check A/Cv on the yellow stator wire make sure the meter has a good engine ground to the black probe. It should...
Forum: 125cc - 249cc 06-06-2013, 03:14 AM
Replies: 35
Views: 69,997
Posted By DW
Your right about the choke but mistaken about the...

Your right about the choke but mistaken about the stator. The stator has 3 separate coils that share a common ground. One coil powers the CDI with A/C and the voltage is regulated by the CDI. Second...
Forum: 125cc - 249cc 06-05-2013, 10:23 PM
Replies: 35
Views: 69,997
Posted By DW
It will vary with rpm's. Checking it at the...

It will vary with rpm's. Checking it at the headlight is the same as checking the yellow wire from the stator. I suspect the stator is your problem.
Forum: 125cc - 249cc 06-04-2013, 01:16 AM
Replies: 7
Views: 12,267
Posted By DW
One fix is to design a muffler mount that bolts...

One fix is to design a muffler mount that bolts directly to the engine casing. Just too much flex in the swing arm.
Some use the spring tension coupling exhaust with good results.
Forum: 125cc - 249cc 05-29-2013, 10:56 PM
Replies: 4
Views: 4,211
Posted By DW
Yes, it will have 1 or 2 grooves in the face of...

Yes, it will have 1 or 2 grooves in the face of the pad.
Forum: 125cc - 249cc 05-29-2013, 09:24 PM
Replies: 4
Views: 4,211
Posted By DW
Sounds like the pad is sticking on the retaining...

Sounds like the pad is sticking on the retaining pin or the piston is getting stuck in the bore. If the pads are past the wear line, replace them. I wouldn't recommend riding it till you get it...
Forum: 125cc - 249cc 05-29-2013, 07:55 PM
Replies: 35
Views: 69,997
Posted By DW
https://lh5.googleusercontent.com/-pv6V1-cHA0c/Uaa...

https://lh5.googleusercontent.com/-pv6V1-cHA0c/UaaLwSQVnGI/AAAAAAAAAGM/Kk3mKgFokao/s1024/GY6Schematic.gif

As you can see, one wire from the stator (yellow) powers many of the lights (including...
Forum: 125cc - 249cc 05-23-2013, 03:55 PM
Replies: 3
Views: 4,755
Posted By DW
Some can be pounded out from the top using a long...

Some can be pounded out from the top using a long drift catching the upper lip of the bottom race.
Forum: 125cc - 249cc 05-16-2013, 05:20 PM
Replies: 35
Views: 69,997
Posted By DW
Sounds like a bad connection to your headlights...

Sounds like a bad connection to your headlights that is resolving itself when you activate another circuit. Look for a pinched wire or bad connection. Wire terminals are often at fault but look ok at...
Forum: 125cc - 249cc 05-14-2013, 12:26 AM
Replies: 35
Views: 69,997
Posted By DW
Could be because I run 35w bulbs instead of the...

Could be because I run 35w bulbs instead of the 25w stock bulbs. However I never had a problem till I took the lighted mirrors off. The wife still has the lighted mirrors on her's with the 35w...
Forum: 125cc - 249cc 05-11-2013, 02:59 PM
Replies: 35
Views: 69,997
Posted By DW
I have the same problem when I use my turn...

I have the same problem when I use my turn signals. Started noticing it after I replaced the lighted mirrors with non lighted ones. However the headlights don't dim at all if I have the stereo amp on...
Forum: Videos 05-07-2013, 08:49 PM
Replies: 4
Views: 5,198
Posted By DW
Was she having an orgasm?

Was she having an orgasm?
Forum: Videos 05-07-2013, 08:18 PM
Replies: 6
Views: 5,382
Posted By DW
Looked like the 2nd up was gonna fall off anyway.

Looked like the 2nd up was gonna fall off anyway.
Forum: Videos 05-07-2013, 08:13 PM
Replies: 6
Views: 7,336
Posted By DW
It's a good thing the rider didn't go down the...

It's a good thing the rider didn't go down the hole. I would have stopped to help the guy.
Forum: Scrappy Dog Scooters 04-27-2013, 04:57 PM
Replies: 11
Views: 17,310
Posted By DW
I could understand it happening once in a while....

I could understand it happening once in a while. But I have ordered from them three times without any successful fit. The first time was a pair of mirrors, ordered from the site. The description had...
Forum: 125cc - 249cc 04-20-2013, 03:40 PM
Replies: 22
Views: 10,825
Posted By DW
Should I be thinking that your fuel tank is under...

Should I be thinking that your fuel tank is under your feet or under your seat in the back? I did hear the valves ticking a bit. I doubt if they are too loose or causing your problem and should quiet...
Forum: 125cc - 249cc 04-20-2013, 03:39 AM
Replies: 11
Views: 15,377
Posted By DW
It seems like the rattling starts when the tire...

It seems like the rattling starts when the tire starts turning. Perhaps your gear lube is low.
Forum: 125cc - 249cc 04-19-2013, 03:41 PM
Replies: 4
Views: 4,297
Posted By DW
Put the battery on a 2amp charger over night....

Put the battery on a 2amp charger over night. Start the engine and check for increase in volts on the terminals. Anything over 14.5v sustained is too high for charging and means regulator problems.
Showing results 1 to 25 of 41
Page 1 of 2 1 2

 
Forum Jump

All times are GMT -4. The time now is 08:07 PM.

Contact Us - ScootDawg.net - Archive - Top
Powered by vBulletin® Version 3.8.4
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.